AZ: Reloading Accident Fires House; Bullets Bounce off Firefighters, Trucks

Picture courtesy 12news.com

A house fire in Gilbert, Arizona, appears to be a rare case of a reloading accident getting out of hand. No one has determined the cause of the accident. I hope that smoking was not involved. One of the things forbidden to reloaders is to smoke while engaged in the hobby. The reloader suffered burns to his face and upper body. That is likely why the fire got out of hand. It would not have taken much to get the three vehicles out of the garage. Their loss was certainly a substantial percentage of the total loss of the house, which looks to be in the $200,000 range. From 12news.com

Sad, all that ammunition going to waste, not to mention the vehicles and the house...

But when you consider the millions of reloaders in the United States, this sort of accident is extremely rare. This is the first one I have heard of in 50 years. Yes, I have been reloading that long.

Notice that the bullets did not have enough force to penetrate the fireman's protective gear, or even do more than chip paint on the fire trucks.

Firefighters have known for years that burning small arms ammunition produces a very low level of danger to firemen. This is from the SAAMI paper, "Facts About Sporting Ammunition Fires":

Ammunition fired in the open, not enclosed in a gun's chamber, discharges with such inefficiency that the projectile will not even penetrate an ordinary fiberboard shipping container panel at very close range. When not strongly and tightly confined, smokeless propellant powders burn relatively slowly and do not explode as we know they do when fired in a gun. Pressure within a cartridge case must build up to several thousand pounds per square inch to cause the cartridge to discharge as it does in a gun. Unless it is tightly confined, as in a gun chamber, no ammunition shell case will withstand the growing pressure of gases generated by burning propellant powder without bursting before the bullet or shot is expelled with violence or velocity.

Casings propelled by this type of action would have to impact exposed skin or eyes to have any effect. Notice what appears to be a 12 gauge metal base and a 9 mm bullet lying together in the street. Of course, the photographer might have put them together for dramatic effect.

The point is that they have little velocity to do damage, and are not very dangerous. Gunpowder is somewhat less flammable than gasoline, and we do not worry about people having much more gasoline than people have, generally, gunpowder for reloading cartridges. Even 10 gallons of gasoline is equivalent to 70 pounds of gun powder, which is enough for 100,000 rounds of 9 mm or .45 ammunition.

Â©2016 by Dean Weingarten: Permission to share is granted when this notice is included.
Link to Gun Watch

The sides of the cases will blow out, the bullet goes one way, cases, the other, with very little power. I’ve seen it in a house fire before, and there are a lot of things to worry about besides this.

I have reloaded since I was 13, and I’ll be 59 in April, but I only shoot up about 6-7000 a year. I have about 20000 loaded rounds and 130 pounds of powder in the house. I’ve never had a safety issue from reloading.

As someone who went from complete ignorance about reloading (before the internet,) to reloading for 25.06, 30.06, 35 Whalen. Use very simple common sense, follow the information relative to what your reloading (6.5 Creedmoor.)

For those not familiar with the 35 Whalen, it was a "wild Cat{er}," i.e., you had no choice but to reload for it. It's also known as a poor man's 375 H&H (ballistics's for the first 100 yards approx. the same.) More then big enough for any game in North America.

Disclaimer: Opinions posted on Free Republic are those of the individual posters and do not necessarily represent the opinion of Free Republic or its management. All materials posted herein are protected by copyright law and the exemption for fair use of copyrighted works.