Posted on 10/31/2015 7:59:14 PM PDT by Tolerance Sucks Rocks
(CNSNews.com) – Following an investigation by its inspector general, the Department of Energy has issued a new rule advising its workers to refrain from putting highly enriched uranium in their pockets.
“After interviewing chemical operators and reviewing revised Y-12 procedures, we confirmed that chemical operators are no longer allowed to place samples in their pockets and must check their pockets before removing their coveralls,” said a report issued by the DOE Office of Inspector General.
The report, released in September, described a safety violation that occured last year at the DOE’s Y-12 National Security Complex in Oak Ridge, Tenn.
"We received allegations that special nuclear material (SNM) was not appropriately managed at the Y-12 National Security Complex (Y-12)," said the IG report. "Specifically, we were informed that on January 22, 2014, highly enriched uranium (HEU) samples were discovered in the pocket of coveralls located on a laundry truck that annunicated an alarm as the truck tried to exit Y-12s Protected Area."
The DOE's Y-12 National Security Complex is involved in the manufacture of nuclear weapons, according to the department's Y-12 website.
"Y-12's core mission is to ensure a safe, secure, and reliable U.S. nuclear deterrent, which is essential to national security," says the site.
“Every weapon in the U.S. nuclear stockpile has components manufactured, maintained or ultimately dismantled by Y-12, the nation’s Uranium Center of Excellence,” the website stated. “We employ only the most advanced and failsafe technologies to protect the stockpile.”
According to the report, when there is a safety violation inside the facility, workers who discover the violation should “establish at least a 15-foot boundary around the samples, make no attempt to correct the situation, and notify Nuclear Criticality Safety (NCS) about the discovery.”
This is known as Y-12 procedure Y56-001, Abnormal Condition Involving Fissile Material.
This “mitigates the risk of adverse health effects such as radiation sickness, increased risk of cancer, and possible death,” according to the report.
“NCS determined that the requirements of the procedure to establish a safe stand-off distance were not met,” the report stated.
“We determined the requirements were not met, in part, because it was unclear as to whether Y56-001 procedures applied outside of the production facilities, as in this case. Also, we were told that training on this procedure did not specify that the procedure should be used outside of the production facilities,” the report added.
The inspector general’s review of the incident “revealed that Y-12 had not completed corrective actions concerning: 1) a safety violation that occurred during the discovery of the HEU samples, and 2) the untimely notification to the Plant Shift Superintendent Office (PSS) about the discovery of the HEU samples.”
After the inspector general’s office notified Y-12 officials, they agreed to implement corrective actions for both issues, according to the report.
Also, the report noted that PSS officials were not notified of the incident until about eight hours afterwards, whereas PSS officials are supposed to be notified immediately about such safety violations, according to Y19-115, Reporting and Handling Security Concerns and Events.
According to one employee at the facility, they assumed that PSS was already aware of the incident, but could not remember who notified PSS or when PSS was notified. “This confusion led to the delayed PSS notification,” the report stated.
Officials at the Y-12 facility have taken steps to improve the tracking and handling of highly enriched uranium and other special nuclear material, the report noted.
“Although Y-12 already had a bar code tracking system in place prior to the incident, SNM samples were exempt from bar code tracking because SNM samples were considered Category IV nuclear material due to their low weight,” the report stated.
According to a Y-12 Subject Matter Expert (SME), the possibility of “a nuclear criticality accident occurring during the incident was very low,” because the “minimum critical mass” for such an incident is over 700 grams, while the samples in question only contained 20 grams of uranium. Also, personnel wore proper protective equipment.
CNSNews.com contacted the Department of Energy with questions about the report, but the DOE has not responded.
Nuclear Nanny State PING!
D’oh!
“Is that uranium in your pocket or...”
HA!
Why is the Government Trying to Control Everything I Do!?!?!?
Darwin Award.
This hurts me to say but I have to man up and say it.
Sometimes Existential Cage Theory just isn’t a viable option. On the positive side, putting HEU in your pocket saves a cage for another idiot liberal to occupy.
And don’t put liquid drano in your coffee.
If uranium is banned, only terrorists will have uranium.
Don’t use superglue to secure your dentures.
If they have to issue this rule, I’m more worried than ever about our nuclear programs.
This is what over regulation does. Soon you will have to write laws against lighting your beard on FIRE. Because if an activity is not regulated then you that activity is safe.
Knew we’d see that classic Simpsons nuke pic
Oh? K...
Seems like good advice.
Thnx
Any hints on next years crops?
I was surprised it wasn’t up there already!
We’re talking about Oak Ridge, TN where components for nuke weapons are made.
The very idea that someone would, even temporarily, put enriched uranium in their pocket— well, let’s just say that person should be fired... on the spot.
The reference to the “criticality” event is indeed scary. Looked it up and it involved the leakage of a 55 gal drum of fissile material solution that had been allowed to accumulate. 7 people exposed, not killed immediately, but all developed early cancer and died.
Weapons grade uranium— you don’t put it in your pocket.sheesh. Spent uranium you make into 20 mm cannon rounds for a Warthog close air support plane.
Disclaimer: Opinions posted on Free Republic are those of the individual posters and do not necessarily represent the opinion of Free Republic or its management. All materials posted herein are protected by copyright law and the exemption for fair use of copyrighted works.